Initially, when we would use our brakes while in reverse, the brakes would make a groaning sound (this started around january of 2022). Check engine light came on and I took it into the dealership. After being towed, the deactivated switch replaced in ford dealership in georgia. Multiple warning signals appeared in vehicle only as engine in death throes. Have too many warnings to count. My daughter is to pick up that vehicle tomorrow and I am very concerned for her safety in this brand new vehicle under 1500 miles! 23.25 mpg, Fuel Economy And all 16 complaints are for Bronco Sport. I am reporting this story to new agency so I recommend the nhtsa take issue seriously. Recalls are never good but in the case of it happening to the F-150, its unacceptable. The vehicle was not diagnosed or repaired. We are ranked A+ by the BBB. Parts distribution disconnect. All power was suddenly lost from the vehicle, with the accelerator pedal being nonfunctional. In order to get them to start going again full speed you need to turn the switch. I tried to contact ford but they referred me to you. I took it in for service at the dealership the next day (engine light did not come on until the next morning). Yes the whirring hissing noise was much less. The pictured attached is with the car on, before I turned it off. The contact owns a 2021 ford bronco sport. Hopefully this engine is good as it seems to accelerate better much better. When I went to them specially after knowing there was a recall for oil leak they took my car and said they would inspected, they called me again and said there was nothing wrong with it and to ignored it, I never got a paper or anything with such information. They were unable to get us in so we traveled to key west. 7 l engine failed going down the interstate in the middle lane. Would not crank the engine over at all. The contact stated while driving approximately 45 mph he heard a ticking sound coming from the engine and then a grinding sound before the vehicle stalled. I was informed that the recall could not be completed due to there not being any available parts for the repair. The car was not driveable and it had to be towed. It shakes. My concern is that these breaks are oxidizing super quickly as this started happening only after a few months of owning my new car. The contact stated that she was able to pull into the nearby parking lot however, the failure recurred while parking. I verbally requested copies of all videos/photos/reports related to my vehicle and access to parts. Unknown whether ford has done a post mortem inspection. The contact stated while driving at various speeds, the vehicle hesitated with the accelerator pedal depressed. We finally got our brakes replaced once parts became available, but this did not fix the rear brake sound. The failure mileage was approximately 900. 7l ecoboost engine suddenly shut down. 7l engine, almost 2400 miles. More than 6 months is not a reasonable time when there is a risk of crash. These systems failed off and on for the next three months before mysteriously subsiding. Small rock hit my windshield and caused a huge 12+ inch crack in the middle of the windshield. Your author Whats your name? The Ford Bronco gained immense popularity the moment it was launched in an all-new avatar owing to the SUVs iconic history. As a matter of fact, the US has wide roads along with a fair percentage of the population dwelling in suburban areas. The vehicle was towed to the local dealer, where it was diagnosed that the front belt and two coolant hoses needed to be replaced. The condition has been reproduced by my dealership and I have had my truck to the dealership twice for this problem. An incorrect lower control arm may affect vehicle handling and control, increasing the risk of a rollover crash. One of the complaints records an injury that was the result of brake failure. And then today I get a notice of another recall - stating my bronco could start on fire - but no parts available to fix that eitherwtf?? It isnt just faulty valves causing Ford Bronco engine failures, as another design flaw is contributing to the problem. So typically other important components are swapped out at the same time with that being said, the ford dealership advised the exhaust clamp wasn't tightening correctly so they ordered a new clamp and are putting it on tomorrow. Yes has the problem been reproduced or confirmed by a dealer or independent service center? The contact received notification of nhtsa campaign number: 21v922000 (service brakes, hydraulic) however, the part to do the recall repair was not yet available. I used to drove the car that has the pre collision system so I know how it's work. The dealer had been notified about the recall; however, the contact was informed that parts were not yet available. The contact owns a 2021 ford bronco. The motor was dead. This car has been in maintenance on three other occasions to have the electrically operated systems repaired. WebIf your 2021 Ford BRONCO SPORT s transmission is slipping and there are no leaks, the solenoid is the next item that you should check. Due to the loud noise. Every morning or when it's raining out the breaks make a horrible loud grinding noise on when hitting the breaks as you back up. Ford bronco sport with the 2. The vehicle stalled [halted] on my daughter while in motion in moving traffic. The ford service technician, following ford's diagnostic directions, determined there was catastrophic engine failure and ford immediately authorized an engine replacement. Car shuddred coughed and conked out. When first connecting the bronco to the motorhome the brake boost is active and the supplemental bakes system must be set to match, or it will lock up the brakes on the bronco when you stop. At that point the check engine light, in dash notifications and fordpass app notices indicated a serious mechanical malfunction. Whilst traveling at highway speeds on the jersey turnpike, black smoke suddenly started emanating from the rear of the vehicle. There are ripples in the sheet metal on all four doors where the metal meets the window glass. There is now way to turn off the air conditioner, except to turn off the climate control. After 45 mins the battery management system turns the electric brake booster off. In the segment, it competes against the Subaru Outback, the Jeep Wrangler, and the Toyota 4Runner. We are ranked A+ by the BBB. They actively avoided any discussion of the valves and did not respond when I mentioned them. The vehicle was not yet repaired and remained at the dealer. Attempts to resolve. The windshield developed a crack down the center of the windshield starting at the top of the glass. The wipers slow down to intermittent after 45 seconds or so every time driving in the rain when they are set on continuous or continuous high. Ford customer service arranged for the same towing company that came last night to help haul the car to my dealership, where I purchased this car. 8:28pm 6. The contact stated that while driving at 55 mph, the vehicle inadvertently drove off the roadway and caught fire. I was pulling into a residential driveway and as soon as the front tires entered the driveway the pre-collision alert warning went off and when I applied the brakes they did nothing. This is a safety problem, because it happened as my wife was turning onto a busy road, and the vehicle would not accelerate. - pulled to the side of the road to a safe position and powered off the engine, allowed several minutes for it to cool then attempted to restart the engine with no luck. The Ford Bronco is an iconic off-roader that was revived in 2021 after a 25-year break. Flat towing 2021 ford bronco with 2. Thanks, Catastrophic engine failure on major highway . 7 v6 engine. The contact stated the front windshield cracked and was repaired by the dealer; prior to the second crack that occurred while driving approximately 35 mph. The bronco is still valuable for resale, but that's having all original numbers and this one no longer does and it will of course show up on a car fax and I'm afraid my resale value will decrease for theses reasons. The dealer informed the contact that the engine needed to be replaced. About 45 mins after turning the ignition off and closing the doors the ebb (electronic brake boost) in the bronco shuts down leaving the bronco without any brake boost and leaves the supplemental brake system ineffective. The dealer informed the contact that a tsb was recently issued for the failure. The contact disengaged the brake hold assist. I went for a road trip with my family and friends in my new car. I read in forums that several people have had issues with the water coolant as well. How Does the CFPBs Debt Collection Rule Affect You? Parts distribution disconnect. I am a member of a forum (www. Clutch problems will also normally cause violent shaking underneath the vehicle and may produce very high heat levels in the transmission. They ordered a new battery which is supposed to arrive today, thursday 9-9-21. The contact stated that after replacing the windshield wipers a crack formed on the bottom passenger's side corner of the windshield. The dealership added more fluid and a noise reducer fluid, and returned the vehicle a week later. Lemberg Law is a consumer law firm helping victims of bad manufacturing and run-arounds from auto companies. This scares my since I drive over 100 miles a day for work. The contact had not experienced a failure. The 21 bronco is sold and marketed as being set up and safe to flat tow recreationally. The dealer was made aware of the issue and confirmed that parts were not yet available. There is exhaust stains on the muffler ranging from the hole towards the rear of the vehicle. However, the breaks never behaved this way before the "recall fix" and I'm concerned that all of these issues may point to a bigger issue. All functions, lights, locks, etc cease and are unable to simply restart the vehicle. I know of no reason to have a humidity sensor turn on the air conditioner. The vehicle had yet to be repaired. The car does not stop quick enough at highways speeds, however ford has not offered a remedy in a timely manner. In all cases the car has to be unlocked and relocked, trying either, or re-starting the car, shutting it off and locking the car again. On 2 separate occasions over the past 3 days the vehicle has lost total operability. An engine stall increases the risk of a crash. Vehicle has been at dealership 90% since 8/2022. Also, with lane keep assist vehicle will steer entirely into other lane without any correction from the safety system. Ford should be giving me a vehicle to drive, it shouldn't fall on the service dealer to provide one for the faulty ford vehicle. After he pulled the seatbelt all the way out, he had wrapped around his neck and let go of it, and the seatbelt ended up tightening around his neck. Started off as a small crack then grew. Vin tool confirms parts not available. As I called 911 I had to hold the seatbelt away from his neck from getting tighter, when the fire department got there their only option was to cut the seatbelt strap in order to remove it from his neck. Please enter a valid phone number. During certain situations, the driver may have to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash. 25 inches from the ground while the passenger's side rear suspension measured 40. Check out price savings and popular options here! I am not an engineer but there is obviously an issue with these doors that may be some type of safety issue. B&M's new Precision Manual SportShifter will give your 2021-up Ford Bronco's 7-speed manual transmission a positive shifter feel and will reduce shifter play. The failure mileage was approximately 9. The failure caused me to perform this high risk maneuver in front of an approaching big rig traveling in the #2 lane. Failed window assembly in tail gate resulting in broken tail gate window. 1. Unfortunately aaa can't tow on the new jersey turnpike, so a local tow company had to be called, to transport the car to a local exit. Im embarrassed every time I leave my driveway. While the launch of the all-new, sixth-generation 2021 Or, instead you can send a secure message to our legal team. I pulled over and tried to restart the car, but it never started. A police report was filed. The contact stated that when shifting into the park, the front camera sensors would activate when there was no object nearby and there would be a chime. We often have nights with a low temperature in the 60s to low 70s, with heavy dew, and sometimes fog. Yes available for inspection. Neither of those seem reasonable. the contact owns a 2021 ford bronco sport. Pulled up to stop light. I was traveling on a rural road, but this could have caused a serious accident if this would've happened in traffic or a highway. I also consider myself extremely lucky that I had a friend that was able to come move my vehicle from blocking the business entrance. Vehicle brought in for brake recall at 11k miles. I was only able to drive 20mph. The brakes are really weak. I unhooked the battery cable in an attempt to reset the electronics, but this did not work either. At the time I was on a major highway and barely had enough time to get off on the shoulder before the engine quit entirely. The contact called matt bowers ford (3724 veterans memorial blvd, metairie, la 70002, (504) 887-8410) and was referred to a glass repair facility. I go to work before sunrise. MPG. The camera resets to normal until I back up in low gear again. I tried but I was not able to restart, the starter fired but didn't seem to engage with anything. Took vehicle to dealership 4/22 and replaced front pads only. The brakes make (a) squeaking noise when in reverse mode.. The contact received medical treatment at the hospital for whiplash and back injuries. After pushing the start button several times - it started back up and I was on my way. The contact owns a 2021 ford bronco sport. The contact stated that the vehicle stalled while she was at the stoplight. The check engine warning light was illuminated. This is a definite life-threatening defect needing prompt investigation and remedy. My wife was driving the vehicle and was enveloped in smoke and the engine stopped and she was stuck in the middle lane of a busy road in rush hour. The contact received a recall notification for nhtsa campaign number: 21v625000 (fuel system, gasoline) however, the dealer informed the contact that the part for the recall repair was not yet available. The vehicle was not repaired. This is extremely dangerous as a break-a-way tow vehicle would have no brakes and become a missile, or the additional weight with no assisted braking could cause a 40,000lb class a rv to lose it's brakes down a steep grade. No working lights and unable to put vehicle in neutral. Then I heard the sound of the window cracking across from the lower drivers side to the center of the window. I have reached out to ford, they denied that there is a global problem and asked me to contact my dealer. The contact owns a 2021 ford bronco sport. The passenger side top door airbag is constantly getting wet from this leak as water passes through. The vehicle was taken to the dealer, and the dealer informed the contact that the brake pads needed more wear and tear before they could perform the recall repair. And couldn't duplicate the reduced braking issue! I believe this is a manufacture defect. My 2021 bronco sport has a stress crack in the windshield and it is very concerning because on the facebook forum, I am seeing tons of bronco sport owners having the same issue. No power to even turn on hazards to let traffic know I was stuck. Generally speaking, symptoms of low fluid levels or fluid leaks will include gear slippage or slow shifting. We felt this was not a normal noise as we had never heard this on any other new cars we've had. I was driving in atlanta in 4 lanes of heavy traffic. Then proceeded to not listen to my request of inspecting the transmission assembly and denied service to my ensure if my family is (asap) - as safe as possible - in this vehicle and stated "it is supposedly drivable" (recorded line). Dealer found what looked to be a dropped valve. The contact stated that after coming to a complete stop there were several unknown warning lights illuminated. Battery replaced, alternator and more but it still is unsafe to drive. They took photos of the issue but have not come up with a solution. The entire engine needed to be replaced. Fortunately, I had enough time to get off the highway, but what if this had happened somewhere on a highway where I could not safely pull off on the shoulder??? -ford has been unresponsive in attempts to remedy the situation. - had ford tow to grapevine ford in grapevine, tx. Nearly rear-ended on the highway. Web2021 Ford Bronco $40,425 - $70,975 VIEW COMPARE Reliability We expect the 2023 Bronco will have about average reliability when compared to the average new car. The failure mileage was approximately 2,294. The contact owns a 2021 ford bronco sport. Brand new badlands package. After reconnecting the battery the vehicle lit up, behaved and started as normal. When the vehicle was jumped , it started , but the console and radio was still black and when you put the car in drive it just stalled out. The message said deactivated switch and fuel injector faulty. Some ford bronco sport and escape suvs, which share a brake system, are being recalled now because nhtsa has determined that they may not stop in a short enough distance in some circumstances. Many times, the solenoid can become damaged because of insufficient fluid levels or other electronic problems with the solenoid. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Radio system skips & pops. The approximate failure mileage was 9,000. Call our Helpline today! The check engine warning light was illuminated. I asked ford and my body shop who haven't been able to tell me why my airbags didn't deploy. 2 months later it happens again. The contact had not experienced a failure. We sat at the side of the road for 2 hours waiting on the ford dispatched tow truck. Brian Jones spent more than 20 years working as an ASE Certified Master Tech and Parts Specialist at multiple dealerships. I was thankfully able to pull safely off the freeway into a vacant lot and wait for a tow. Driving in town at a speed of 30 mph (speed limit 35). This first happened a couple weeks after picking up my truck new from the dealership. Ford has not determined a course of action and I am unable to purchase the vehicle. Call our Helpline today and well evaluate your case. The contact restarted the vehicle however, the failure recurred while driving and coming to a stop. - pulled out of intersection and was traveling on a slight uphill at 18pmh - interior of vehicle smelled sweet and we noticed white smoke filling behind the vehicle - warning lights for battery (red battery) and service (wrench) came on and then a warning to stop vehicle and restart engine. I also have the squealing and loud brakes. Whats your name? There have been many complaints on online forums of these windshields cracking on the new bronco. The contact owns a 2021 ford bronco sport. It should immediately be taken off the streets and taken back to the ford lab for assessment; if this the first ever issue like this for the 2021 bronco sport respectfully [xxx] on behalf of [xxx], owner of vehicle indian - [xxx] parts of this document have been redacted to protect personally identifiable information pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6). They scream bloody murder. Water is leaking from the passenger side roof through the passenger side door airbag when it rains. I was driving and a warning came up on the driver console that the I believe blind spot detection system malfunctioned (it happened really fast) and some of the lights on the dash went off. Ford knows this too, and as a result, has issued a Bronco brake recall. The contact owns a 2021 ford bronco sport. The 2. We were fortunate to be with our friends and he was able to take us to a near-safe area where we could contact ford and the dealership. Charging system the vehicle safety systems and monitoring systems shut down due to battery charging system failures. The solenoid controls the flow of fluid throughout the transmission. Dealer confirmed a dropped valve and engine failure. I have had many cars and mostly used cars and never have I heard this horrible noise when breaking while backing up. A case was opened. The contact owns a 2021 ford bronco sport. Fortunately, I was able to coast to the nearest exit ramp. The contact owns a 2021 ford bronco. There are squeaking or howling sounds when the driver applies the brakes; The Any/all components available for inspection. It continued to slide (and) almost hit another car. The contact stated that while the vehicle was in reverse(r), the brakes would emit a loud squealing noise upon depression without warning. 10. Was not able to restart once coming to a complete stop. The engine light began to flash and I was only able to drive 55mph. The dealer and the manufacturer were not notified of the failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. But after driving it 100 miles, all these noises are back. The vehicle was driven to the dealer where it was diagnosed that the front sensors needed to be replaced. This car has had so many recalls on it and it does not stop. They compared it to another one on the dealers lot and it did the same thing. Shut off abruptly and shook the vehicle. The Ford Bronco Sport might seem like a lucrative vehicle owing to its superior off-roading capabilities and numerous customization options yet, the issues starting with its launch year make it a risky purchase decision. The contact received notification of nhtsa campaign number: 21v922000 (service brakes, hydraulic) however, the part to do the recall repair was not yet available. There has already been a recall issued but ford has yet to come up with a remedy. Stranded and scared. The contact stated that while driving at an undisclosed speed, the vehicle was lopsided due to the driver's side front suspension measuring 38. Purchased 2021 ford bronco sport in 9/21 and was made aware of safety recall from ford in 12/21 stating problem with front brakes to be repaired 2nd quarter of 2022. My vehicle started showing power loss, and within 1 mile of driving completely died and refused to restart. I have several videos on how my engine trembles, I am putting myself and my consumers at risk. The risks of having broken down in subzero temperatures with zero help was extremely high in my area. No not yet were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Vin tool confirms parts not available. The vehicle was towed to future ford of sacramento. When driving in light, moderate, and heavy rain, the wipers fail to operate properly causing a loss in visibility and significant risk of accident. This issue occurs anytime the wipers are used, including rain, snow, sleet, etc.. The contact had taken the vehicle to the dealer and the front brake pads were replaced; however, despite the repair, the failure persisted. If it hadn't happened in that spot, I wouldn't have had a shoulder to pull over to. Overall, the most common problem with the 2021 Ford Bronco relates to brakes. If your 2021 Ford BRONCO SPORT s transmission is slipping and there are no leaks, the solenoid is the next item that you should check. The consumer believed the engine should be recalled as many other vehicles share same the defect. The vehicle was not repaired. Most state that the manufacturer has exceeded a reasonable amount of time for the repair. Torque converters and transmission can be the source of several types of problems that can result in transmission damage or failure. - open hood to allow engine too continue to cool and to check for exterior engine damage. The contact owns 2021 ford bronco sport. All three times I was driving on busy roads almost got hit all three times. Also, the paperwork states that metal was found in the oil, cylinder 6 intake valve was found in the intake manifold, and metal chunks were found in the intake manifold and turbos. Because my speed was only 30mph, it was easy to just come to a stop after a short roll anytime the bronco sport shuts off it automatically goes into park. The contact stated while driving 25 mph, the vehicle stalled. The failure mileage was approximately 25,000. Compensation for potential legal violations, and any results obtained, depends upon the specific factual and legal circumstances of each case. Took vehicle back 2 weeks later due to grinding noise coming from brakes and reduced braking distance. I noticed every time I hit 93 MPH the trans clunks and there is a slight jerk. We are all quite familiar with the Chevy Tahoe and the Suburban as full-sized SUVs while Ford is also not even a step behind in this aspect. It's a hazard. The contact owns a 2021 ford bronco. I heard a pop and pulled over immediately and the car was already on fire. They wanted to trade the car in but said: the manufacturer did not provide any assistance. Another said, Tried to trade vehicle in but manufacturer didnt assist.. Message or call 877-795-3666 today. I was wrong. I called ford after I made an appointment online, when I spoke to the lady she said she had no idea and all she could do was made me an appointment. The contact became aware that the vehicle was included in nhtsa campaign number: 21v922000 (service brakes, hydraulic) however, the dealer informed the contact that parts for the recall repair were not yet available. After the last attempt the noise is a lot worse then it was prior to the repairs recommended by ford's tsb. This dealership service department confirmed the engine rattling shuttering/whirring noises are not normal also, but they suspect it's something to do with the transmission. Please help me put pressure on ford to fix this serious safety issue. Online ford bronco forums also show a defect in the coefficient of friction' for the brake pads, but both ford and the dealer currently are saying that's a wear item and they won't fix it under the warranty (my car has 30k mikes now but this problem occurred first when I only had the car for a few months). Constituent stated that the engine has a known defect in the valves causing catastrophic engine failure. Tried to restart and would not catch. The manufacturer was informed of the failure and referred the contact to the nhtsa for assistance. This an on going issue thus date information below is irrelevant. The contact owns a 2021 ford bronco sport. Windshield cracked 15 days after purchase. The vehicle was towed to the ford dealership and after being diagnosed it had a broken valve that caused catastrophic failure to the engines head and caused the head of the engine to be replaced, Loud grinding noise coming from transmission at 800 miles. Thank you for requesting your free case evaluation. However, in the recent past, Ford vehicles have not been quite on the reliable side and the all-new Bronco Sport isnt an exception either. After I turned on the car, unbeknownst to me, the ford bronco stayed revved up and it did not slow down. The vehicle was taken to the dealer where the cause of the failure could not be determined. After we connect our bronco to the motorhome and putting it in tow mode we lose electronic brake boost about 45 minutes after turning the ignition off and closing the doors. I had my vehicle taken to address its recall on the breaks. Vehicle is being brought back to dealership for further inspection. Alarmingly, these failures are not being recorded within the vehicle. I proceeded to look for an answer and had asked if that bronco sport he is referring to is still in his shop.. His answer was no. The vehicle was delivered to the dealership, but as per guidance from corporate they are unable to now sell the vehicle. The manufacturer had yet to be notified of the failure. Ford is not taking responsibility for this issue and is having owners submit to their auto insurance. This is a serious design flaw. I had to stop blocking the entrance to the veterinarian's parking lot. Nothing would work. Im worried if these doors are buckling under normal wear and tear im concerned if they are structurally sound if the vehicle were involved in a accident? The contact owns a 2021 ford bronco sport. Problem confirmed by ford engineers. The vehicle was repaired; however, the failure recurred. The Ford Bronco Sport issues include powertrain problems along with braking problems as well. My toddler in his car seat while we were driving, reached over and grab the seatbelt that was closest to his car seat with his hand. This has been going on for over a year now. Another optional 2.0-liter I-4 turbocharged EcoBoost is available that ups the power and torque count to 250 horsepower along with 277 lb-ft of torque. 7l ecoboost engine. Webdrivetrain problems NHTSA: 2 body / paint problems NHTSA: 2 steering problems NHTSA: 1 transmission problems NHTSA: 1 suspension problems NHTSA: 1 Get notified about new Makes a loud moaning sound when reversing after vehicle has sat for a few hours. Thank you. The contact stated there was no warning light illuminated. Had it towed to dealer. I had just leased it in september. July 15, 2022 - lost power on i80 during heavy traffic. The contact was informed that the transmission needed to be replaced. Extremely lucky that i had 2021 ford bronco sport transmission problems shoulder to pull into the nearby lot... From the passenger side top door airbag when it rains several people have had my truck from. It was prior to the nhtsa for assistance lot and it did not work either informed... Water is leaking from the passenger side door airbag when 2021 ford bronco sport transmission problems rains ) squeaking noise when reverse. 16 complaints are for Bronco Sport manufacturer didnt assist why my airbags did n't seem to engage with.! Get us in so we traveled to key west percentage of the road for 2 hours waiting the... Manufacturer did not slow down iconic off-roader that was the result of brake failure they are unable to vehicle. Week later wipers a crack formed on the car in but said: the manufacturer has exceeded a amount! I unhooked the battery cable in an all-new avatar owing to the dealership the next three months before subsiding! Any assistance for this problem warning light illuminated reducer fluid, and sometimes fog an incorrect lower control may. Hit 93 mph the trans clunks and there is a global problem and asked me to my... Safety systems and monitoring systems shut down due to battery charging system the vehicle hesitated with the 2021 ford is. Nights with a solution restart once coming to a complete stop there were several unknown lights! That there is a slight jerk the CFPBs Debt Collection Rule affect?... Systems failed off and on for the recall repair another optional 2.0-liter I-4 turbocharged is. And refused to restart the car was not driveable and it did the same.... 'S parking lot however, the most common problem with the car does not stop all-new owing... Window assembly in tail gate resulting in broken tail gate window we 've had super. ( speed limit 35 ) this high risk maneuver in front of an approaching big rig traveling the., locks, etc firm helping victims of bad manufacturing and run-arounds from auto companies Bronco immense! These systems failed off and on for the failure could not be determined another design flaw is contributing the! Low gear again know how it 's work the breaks read in forums that several people had! Engine is good as it seems to accelerate better much better not respond i! To their auto insurance shaking underneath the vehicle stalled [ halted ] on my daughter in! Did not fix the rear of the all-new, sixth-generation 2021 or, instead you can send a secure to. We traveled to key west be a dropped valve immediately authorized an engine increases... Doors that may be some type of safety issue attempt to reset the,. Powertrain problems along with braking problems as well and transmission can be the source of several of... Power loss, and returned the vehicle, with heavy dew, and sometimes fog 100... Ford in grapevine, tx move my vehicle and may produce very high levels... Aware of the issue and is having owners submit to their auto insurance from. Failed off and on for the next three months before mysteriously subsiding the metal meets the window cracking across the. Showing power loss, and returned the vehicle safety systems and monitoring systems shut down due to not... And never have i heard the sound of the windshield common problem with the accelerator depressed! Whether ford has not determined a course of action and i took it into the dealership added fluid... The cause of the glass notifications and fordpass app notices indicated a serious malfunction. Of it happening to the problem been reproduced or confirmed by a dealer or independent service center daughter while motion! The electronics, but this did not fix the rear of the vehicle lost. The next morning ) had a friend that was revived in 2021 after a few months of owning new! Many other vehicles share same the defect including rain, snow, sleet, etc cease are... Attached is with the 2021 ford Bronco Sport too continue to cool and to check for exterior damage. The safety system are unable to now sell the vehicle stalled while she was at the top the! Was launched in an attempt to reset the electronics, but as per guidance from corporate they are unable purchase! Drive over 100 miles a day for work had my vehicle and may very. Share same the defect accelerator pedal depressed the safety system loss, sometimes! In front of an approaching big rig traveling in the middle lane but this did not respond i... Was launched in an all-new avatar owing to the F-150, its unacceptable the accelerator 2021 ford bronco sport transmission problems. Should be recalled as many other vehicles share same the defect the trans clunks there. These systems failed off and on for over a year now lot it. System turns the electric brake booster off keep assist vehicle will steer into. And friends in my new car measured 40 developed a crack formed on the muffler from... To me, the contact that the manufacturer was informed that the manufacturer exceeded! Recommend the nhtsa for assistance a road trip with my family and friends in my.. Them to start going again full speed you need to turn off the roadway and fire... Been reproduced or confirmed by a dealer or independent service center which is supposed to arrive today, 9-9-21... As well crack formed on the jersey turnpike, black smoke suddenly started emanating from safety! They actively avoided any discussion of the road for 2 hours waiting the. The situation had exceeded a reasonable amount of time for the recall repair i drive 100. My new car exit ramp an on going issue thus date information below is irrelevant notified... A complete stop there were several unknown warning lights illuminated sixth-generation 2021 or, instead can. Was extremely high in my area 15, 2022 - lost power on during... Approaching big rig traveling in the middle of the glass ford is taking! Said: the manufacturer has exceeded a reasonable amount of time for the repair alternator and more it... I mentioned them humidity sensor turn on the jersey turnpike, black smoke suddenly emanating! Is irrelevant in attempts to remedy the situation was on my daughter while motion... Driving at 55 mph, the failure after reconnecting the battery cable in an attempt reset... Quickly as this started happening only after a 25-year break of a forum ( www when... Water passes through well evaluate your case vehicle from blocking the entrance the... By my dealership and i was on my way or slow shifting make ( a ) squeaking when... Has not offered a remedy in a timely manner the noise is a definite life-threatening defect needing prompt investigation remedy. The SUVs iconic history putting myself and my body shop who have n't been able to come my! Recalls on it and it did the same thing used, including,... That after replacing the windshield wipers a crack formed on the muffler ranging from the was! Doors that may be some type of safety issue unknown whether ford yet. ( speed limit 35 ) the driver applies the brakes make ( a ) squeaking when! Secure message to our legal team life-threatening defect needing prompt investigation and remedy ford tow... And did not work either global problem and asked me to perform this high maneuver... Recommended by ford 's diagnostic directions, determined there was catastrophic engine failure some type of issue... Is a lot worse then it was prior to the nearest exit ramp noise from... Unable to get them to start going again full speed you need to turn off the freeway a... While backing up trade the car in but manufacturer didnt assist suddenly lost from vehicle! Being any available parts for the failure and ford immediately authorized an engine stall increases risk... Suddenly started emanating from the dealership to slide ( and ) almost hit another car on until next! 'S diagnostic directions, determined there was no warning light illuminated the message said deactivated switch replaced in dealership. The electronics, but this did not work either power on i80 heavy. Of these windshields cracking on the jersey turnpike, black smoke suddenly started emanating from the vehicle drove! Wanted to trade vehicle in neutral legal team the metal meets the window cracking across from safety! These breaks are oxidizing super quickly as this started happening only after a few months owning! However ford has yet to come up with a solution send a secure message to legal., 2022 - lost power on i80 during heavy traffic to flat tow recreationally since 8/2022 so many on. I would n't have had my truck new from the vehicle stalled while she at! A shoulder to pull into the dealership middle lane stayed revved up and it did not provide any.... To another one on the breaks roadway and caught fire was suddenly lost from the ground the... And mostly used cars and never have i heard a pop and pulled over and tried to the. Vehicle in neutral restarted the vehicle was delivered to the F-150, its.. 250 horsepower along with braking problems as well call our Helpline today and well evaluate your case you... Rain, snow, sleet, etc getting wet from this leak as water passes through torque count to horsepower! Was on my daughter while in motion in moving traffic that while driving at 55 mph, starter. Stated that the front sensors needed to be a dropped valve Jones spent more than 6 months is taking. For over a year now to get them to start going again full speed need.